• Hey Guest!
    British Car Forum has been supporting enthusiasts for over 25 years by providing a great place to share our love for British cars. You can support our efforts by upgrading your membership for less than the dues of most car clubs. There are some perks with a member upgrade!
    **Upgrade Now**
    (PS: Upgraded members don't see this banner, nor will you see the Google ads that appear on the site.)

The Doors...

Share this page

AltaKnight

AltaKnight

Jedi Knight
Offline
No, not the band!
My 73 TR6 passenger door rattles; I've checked by grasping the door handle and the door can move a bit up and down on the latch which causes a clunky noise going over bumps.
Can the latch mechanism be adjusted or is it a case of replacing components?
 
The latches can be adjusted. It's best to get a few paint sticks that are liberally covered with masking tape to use as guides if you loosen the latch on the door very slightly to get the door in proper alignment all around. These can be wedged between the door (without marring the paint) and the body/rocker/fender to keep an even gap all around.

Once aligned, slowly open the door and tighten it down. Then you can check it by just closing the door to touch the striker. If it stayed in the proper place before you tightened it, the door should easily push and click into a locked position. If not, move slightly up or down to get it right.
 
Excessive movement could be the result of worn hinge pins which would require replacement of the hinges. I am not aware of replacement pins.
 
OOP's!! My bad Doug. I assumed that the hinges were checked.
 
Back
Top